Ontario · Energy · checked September 28, 2026

Duct leakage testing in Thunder Bay

If some rooms never get warm, the problem is often the ductwork, not the furnace. In the Thunder Bay area, 84% of households heat with a forced-air furnace, so duct losses affect many Thunder Bay homes.

Get matched in Thunder Bay → Duct leakage and airflow testing
A duct-testing fan on a basement floor connected by flexible duct to a furnace, a pressure gauge hanging from a joist

Typical cost

$200–$450

Forced-air furnaces

84%

Electric baseboards

Not published

Houses built before 1991

84%

How Thunder Bay is built

Thunder Bay's houses by when they were built Ten house shapes, one for each tenth of Thunder Bay's 37,935 houses. Before 1961: 43%, 1961–1990: 41%, 1991–2000: 7%, 2001 or later: 9%. Older houses glow hotter.
  • Before 1961 43%
  • 1961–1990 41%
  • 1991–2000 7%
  • 2001 or later 9%
Each house stands for one in ten of Thunder Bay's 37,935 houses (single-detached, semi-detached, row and duplex), drawn by when it was built. The glow shows the usual pattern: older houses tend to be leakier and less insulated. Snowfall scales with heating degree-days. Sources: Statistics Canada 2021 Census (table 98-10-0233-01), NRCan HOT2000 climate data.

Who needs it in Thunder Bay

In the Thunder Bay area, 84% of households heat mainly with a forced-air furnace; natural gas is the main heating energy for 81% of households (Statistics Canada, 2023).

Of Thunder Bay's 37,935 houses (single-detached, semi-detached, row houses and duplexes), 43% were built before 1961 and 84% before 1991, according to the 2021 Census. Ducts in older houses often run through unheated spaces with taped or unsealed joints, and supply runs to the far rooms are the first to suffer.

What the test shows

  • Total duct leakage, as a share of the system's airflow, measured with a duct-pressurization fan.
  • Airflow at each register, which explains why one bedroom is always cold.
  • Whether sealing and balancing will fix comfort problems before you buy bigger equipment.

Duct leakage testing in detail.

What it costs

About $200–$450 (a September 2026 planning range; quotes vary). It isn't part of a standard EnerGuide evaluation, so ask for it when you book if comfort is your main complaint.

NRCan-licensed service organizations serving Thunder Bay

Duct leakage testing isn't part of a standard EnerGuide evaluation. Some of these organizations offer it, as do HVAC contractors with duct-testing equipment, so ask when you call.

Only assessments from the seven HRSP-approved organizations qualify for the $600 Home Renovation Savings rebate and its assessment-path upgrade rebates; each listing below says whether it's one of them.

Source: NRCan list of licensed service organizations, checked September 28, 2026. Call to confirm your street is covered and ask about wait times.

Programs in Thunder Bay

Provincial · needs an evaluation Home Renovation Savings — Home Energy Assessment path Up to $10,000 per home for insulation, windows and air sealing, plus $600 back on your assessments — if the follow-up assessment is done by December 31, 2026 Open · deadline Provincial Home Renovation Savings — direct rebates (no assessment) Heat pumps up to $7,500 ($12,000 ground-source), solar with battery up to $10,000, plus attic, thermostat and appliance rebates — no assessment needed Open Federal CMHC Eco Improvement premium refund 25% back on your CMHC mortgage insurance premium after $20,000 of energy renovations Open

Duct leakage testing in Thunder Bay: common questions

How much does duct leakage testing cost in Thunder Bay?

Plan on about $200–$450. It is usually a separate service from an EnerGuide evaluation.

Is duct cleaning the same thing?

No. Cleaning removes dust; it doesn't find or seal leaks. A leakage test measures where air is lost.

Should I close vents in unused rooms?

Usually not. Closing registers raises duct pressure and can increase leakage elsewhere in the system.

Duct leakage testing near Thunder Bay

Duct leakage testing in Winnipeg590 kmDuct leakage testing in Greater Sudbury665 kmDuct leakage testing in Windsor846 kmDuct leakage testing in Chatham-Kent864 kmDuct leakage testing in Barrie869 km All 70 cities →

Sources

Checked September 28, 2026. Census figures are for the municipality (Ontario); climate data is NRCan's HOT2000 station Thunder Bay (10 km away).

Get matched with a registered advisor in Thunder Bay

Tell us your postal code and what you’re planning. We’ll connect you with one licensed service organization serving your area. No spam, no shared lead lists.

Email us what you’re planning, your postal code and the type of building (a house, a duplex or triplex, or a larger multi-unit building) — we’ll reply with registered service organizations for your area and which rebates apply.

Email dave@clickshift.ca

This inbox is answered by a person. Participating advisors pay us a referral fee — you pay nothing, and it never affects the directory.